Excerpt from the government of Ontario’s ‘Newsroom’
ArcelorMittal Dofasco Inc., a processor and manufacturer of steel products, has pleaded guilty and has been fined $130,000 after two separate incidents, four days apart, in which workers were injured.
On September 6, 2012, four workers at the plant’s #3 Blast Furnace at the Burlington Street facility were changing a tuyere (a pipe/nozzle through which air is blown into the furnace) and blow pipe assembly on the west side of the furnace. To carry out the task, the workers used a tow motor to elevate the tuyere and move it into place. One worker stood on the front left fender of the tow motor in order to line up bolt holes with the furnace.
The worker stepped down from the fender, lost grip on the mast of the tow motor and fell backwards. The worker fell about 2.5 feet, landed on one foot and stepped on a piece of equipment. The fall resulted in a leg fracture, which is defined as a critical injury under health and safety regulations.
A blast furnace where raw iron ore is smelted and reduced is considered a mining plant and subject to Ontario Regulation 854/90, the Regulation for Mines and Mining Plants. The injured worker was required to service equipment and did not have prescribed access to perform the work. This is contrary to the Occupational Health and Safety Act. (OHSA)
The company pleaded guilty to the violation and was fined $55,000 by Justice of the Peace Jerry Woloschuk.
On September 10, 2012, two workers at the company’s #2 Anneal Cooling Tower in the tin mill on Burlington Street East were troubleshooting a malfunctioning closed-circuit television camera. The workers shut off the cooling fan to prevent dust from being blown around.
One worker then ascended a portable staircase to reach the camera while the co-worker remained at ground level. After ascending and descending the stairs two or three times, that worker was overcome with fumes and lost consciousness, which is defined by regulation as a critical injury. The worker regained consciousness a few minutes later.
Testing showed that the atmospheric oxygen level in the area near the camera was below 10 per cent by volume because hydrogen and nitrogen gases – which are simple asphyxiants – had accumulated in the area after the cooling fan was turned off. Neither worker was protected by mechanical ventilation equipment for working in this area.
The company pleaded guilty to the violation and was fined $75,000 by Justice of the Peace Jerry Woloschuk.
In addition to the fines, the court imposed a 25-per-cent victim fine surcharge as required by the Provincial Offences Act. The surcharge is credited to a special provincial government fund to assist victims of crime.
The law(s) in contravention:
ArcelorMittal Dofasco Inc. was found guilty of a contravention of the Ontario ‘Mining’ regulation 854/90, section 46, subsection (2) states,
(1) “A safe means of access to a workplace shall be provided by a walkway, stairway or ladderway.”
(2) “Where workers are required to work, operate, maintain or service equipment, a safe means of access shall be provided as prescribed in subsection (1).”
ArcelorMittal Dofasco Inc. was also found guilty of a contravention of the Ontario ‘Industrial’ regulation 851/90, section 138(1) which states,
“Where a worker is likely to be exposed to an atmosphere at atmospheric pressure with an oxygen content of less than 18 per cent, the worker shall be protected by mechanical ventilation so that the worker’s safety and health is not endangered.”
ArcelorMittal Dofasco Inc. was convicted for a contravention of the Ontario Occupational Health and Safety Act, (OHSA) section 25, subsection 2 (h) which states,
“An employer shall,
(h) take every precaution reasonable in the circumstances for the protection of the worker.”
It seems many employers do not have the vaguest idea about when and when not to report to the Ministry of Labour (MOL).
A critical injury defined is list in Ontario regulation 834 which states,
“For the purposes of the Act and the Regulations,
“critically injured” means an injury of a serious nature that,
(a) places life in jeopardy,
(b) produces unconsciousness,
(c) results in substantial loss of blood,
(d) involves the fracture of a leg or arm but not a finger or toe,
(e) involves the amputation of a leg, arm, hand or foot but not a finger or toe,
(f) consists of burns to a major portion of the body, or
(g) causes the loss of sight in an eye.”
There is also a regulation that covers a ‘Confined Space’. (Ont. Reg. 632/05) This particular regulation could have been used and there were numerous violations there I can tell you!
Ensure your workplace is a safe place.
Remember – In Ontario, “ALL Accidents are Preventable”
HRS Group Inc. has a great team that can help you with all your health and safety needs including ‘Due Diligence’, ‘Confined Space Entry’ and ‘Standard Operating Procedures’. Contact Deborah toll free at 1-877-907-7744 or locally at 705-749-1259.
We can also be reached at firstname.lastname@example.org
‘Work’ and ‘Play’ safe.
Daniel L. Beal
CHSEP – Advanced Level
VP & Senior Trainer
HRS Group Inc.